4/6/2025, 4:25:36 AM 星期日
光面爆破椭圆双极线性聚能药柱有效功及不耦合系数模拟研究
CSTR:
作者单位:

解放军理工大学,解放军理工大学,解放军理工大学,解放军理工大学

中图分类号:

TD235


Simulation Study on Effective Work and Non-coupling Coefficients of Elliptic Bipolar Linear Shaped Charge for Smooth Blasting
Author:
Affiliation:

PLA University of Science and Technology,PLA University of Science and Technology,PLA University of Science and Technology,PLA University of Science and Technology

  • 摘要
  • | |
  • 访问统计
  • |
  • 参考文献 [8]
  • |
  • 相似文献 [20]
  • | | |
  • 文章评论
    摘要:

    基于动力学仿真软件AUTODYN,对椭圆双极线性聚能药柱(EBLSC)进行了数值模拟。采用二维面对称计算方法,花岗岩岩体,空气夹层不耦合装药条件,研究了EBLSC结构及不耦合系数对光面爆破效果的影响,并建立有效体积功模型以评价爆破效果。结果表明,炮孔连线方向和垂直方向上的比冲量相近,偏差<10%,故总能量沿周向近似均匀分布,但炮孔连线方向产生明显侵彻裂隙,且粉碎圈厚度和腔体扩张程度要小得多,表明该装药结构能够明显提高炸药能量的利用率和爆破效果;随着不耦合系数增大,炮孔连线方向上的损耗体积功先减小后增大,存在最大有效功。利用曲线拟合,得到最优不耦合系数约3.62,与相关文献的试验结果相近。

    Abstract:

    Numerical simulation was done on the elliptic bipolar linear shaped charge (EBLSC) based on dynamics simulation software AUTODYN. First, through two-dimensional planar symmetric method and considering granite characteristics, air sandwich and decouple condition, the effects of EBLSC structure and decouple coefficient for smooth blasting were studied. Then, the effective volume work model was established to evaluate blasting results. The results indicated that the specific impulses on blasthole line connecting direction and in vertical direction were similar with deviation below 10%, so the whole energy of charge uniformly was distributed along the circumferential direction approximately. However, there were obvious penetration cracks in blasthole connecting direction with lower crushing and expanding degree of the rock. It indicated that EBLSC could improve significantly the charge energy efficiency and blasting result. In addition, with the decouple coefficient increasing, the loss or waste volume work in blasthole connection direction first decreased and then increased with the existence of maximum effective power. Through curve fitting, the optimal decouple coefficient of about 3.62 was obtained, which was similar to the result of relevant experiments.

    参考文献
    [1] 尚玉峰. 影响光面爆破效果的因素分析[J]. 南方金属, 1009- 9700( 2008) 03- 0053- 03.
    [2] 宗琦, 杨吕俊. 岩石中爆炸冲击波能量分布规律初探[J]. 爆破, 1999(06)-16-02.
    [3] 吴亮, 卢文波, 宗琦. 岩石中柱状装药爆炸能量分布[J]. 岩土力学, 1000-7598-(2006) 05-0735-05.
    [4] 梁为民, LIU Hongyuan, 周丰峻. 不耦合装药结构对岩石爆破的影响[J]. 北京理工大学学报, 2012(12)-32-12.
    [5] 杨哲峰, 高诗明, 陈建平等. 光面爆破径向不耦合系数优化研究[J]. 科学技术与工程, 1671—1815( 2014) 35-0121-05.
    [6] 秦健飞. 双聚能预裂与光面爆破新技术评析[J]. 土石方工程.
    [7] 李必红, 崔伟峰, 李是良. 椭圆双极线性聚能药柱不耦合系数试验研究及数值模拟[J]. 爆破, 2013(06)-30-02.
    [8] 马建军, 程良奎, 蔡路军. 爆破应力波的传播及其远区破坏效应研究现状述评[J]. 爆破, 1001- 487X( 2005) 02- 0017- 05
    引证文献
    网友评论
    网友评论
    分享到微博
    发 布
引用本文

郭浩然,季茂荣,郭涛,等.光面爆破椭圆双极线性聚能药柱有效功及不耦合系数模拟研究[J].钻探工程,2015,42(11):74-79.
GUO Hao-ran, JI Mao-rong, GUO Tao, et al. Simulation Study on Effective Work and Non-coupling Coefficients of Elliptic Bipolar Linear Shaped Charge for Smooth Blasting[J]. Drilling Engineering, 2015,42(11):74-79.

复制
分享
文章指标
  • 点击次数:971
  • 下载次数: 939
  • HTML阅读次数: 218
  • 引用次数: 0
历史
  • 收稿日期:2015-05-27
  • 最后修改日期:2015-11-13
  • 录用日期:2015-07-10
  • 在线发布日期: 2015-12-03
文章二维码